Part One: Setting the Stage
In mid November 2015 I was faced with a situation.
I had the opportunity to attend a science education workshop at the SciWorks science museum north of Winston Salem, NC almost 200 miles from my home in the Blue Ridge Mountains of Western North Carolina.
This workshop was important to me for not only the knowledge I would gain but also in the hours that I could use to further the completion of my North Carolina Environmental Educator’s Certification.
The only issue was that my wife was out of town with our long range ICE powered vehicle so I was forced to make a decision – miss the class or drive the Leaf on the almost 400 mile round trip.
It was an easy decision – I like a challenge so I decided to drive the Leaf.
But first I would need to do some research to be sure that I would be able to make the trip without much difficulty.
Factor One – The Route
As you can see there would be no issues getting from Brevard to Black Mountain – I have done it many times when I have attended the Leaf Festival (it has nothing to do with the Nissan Leaf). However, between Black Mountain and Hickory there is not a single EV charging station to be found so I dubbed this section of the route – “The Wasteland.” I felt almost positive that I could make the crossing of this stretch of highway without any issues and then continue on to my destination. My resolve to attempt this run was strengthened after my friend and fellow Leaf owner Rudy completed this same route in his Nissan Leaf a few weeks prior. In fact, Rudy’s adventure took him much further than I was going to go – all the way to Chapel Hill – so his accomplishment gave me inspiration to tackle the shorter drive to Winston Salem.
What I failed to factor into my calculations was that “Murphy’s Law” always has a way of throwing unforeseen factors into the mix that often result in undesirable outcomes of which you will read all about in the play-by-play I have outlined for you below…
Factor Number Two – The Car
I drive a 2012 Nissan Leaf SL. It measures available range only in mileage, not in percent of charge remaining as all newer Leaf’s so nicely do. Many owners of this, and earlier model Leaf’s, refer to the estimated mileage range meter as the Guess-O-Meter or GOM which calculates potential range remaining based on many constantly changing factors such as speed, elevation, temperature, accessories being used, and more.
I routinely drive my Leaf in ECO mode in order to conserve as much power as possible so all mileage reports in this document will be for ECO mode unless otherwise noted.
My Leaf has 31k miles on the odometer and it has recently lost its first battery capacity bar.
Factor Three – The Driver
Remember Melville’s story about the white whale…well, in the past I have often looked at driving long distances in my leaf as sort of my “white whale” so to speak. In all other instances I have defeated my whale and always made it to my chosen destination and back using meticulous research, planning, knowledge, driving skills, and a bit of luck I suppose…and fortunately without the undesirable consequences Captain Ahab encountered fighting his whale. On this trip however, due to errors of miscalculation on my part – the whale almost wins.
Day one 11/13/15
Home. 8:30 am. o miles driven. I left home with a full charge and 77 miles on the GOM.
Mills River. 9:00 am. I stopped for a car wash to remove the dirt and grime built up from the last week and a half of constant rains. Not only would the car look nice for the trip but the clean, shiny, paint would hopefully help the car slip through the air a little bit better thereby lowering my drag coefficient resulting in a bit better energy economy…that was my theory anyway.
Asheville. 10:20 am. 26 miles driven, 41 miles remaining on GOM. I made it to my first charging location of the DCQC CHAdeMO unit on the campus of Asheville Buncombe Technical Community College where I plugged into the massive Eaton Level 3 charging unit and filled up the Leaf up to 80% and 82 miles of range on the GOM before heading out to Black Mountain.
Black Mountain. 12:37 am. 17 miles driven, 44 miles remaining on GOM. At this point I was farther east that I had ever been in my little electric car. I plugged into the Level 2 GE Watt station and waked about a block into the middle of the quaint little mountain town and found a bar and grille style restaurant called the Ale House where I had a great lunch. After lunch I headed back to a fully charged Leaf with 72 miles of range so I pointed the car to the east.
The only way to get out of the mountains from Black Mountain, without undue difficulty and copious amounts of time, is to take interstate 40 east over the eastern edge of the Blue Ridge escarpment – a massive wall of a mountain that drops from around 2800 feet above sea level to around 1400 feet in just a few miles.
2:00pm. After leaving Black Mountain with a full charge and getting on interstate 40 I headed up to the gap in the ridge where I found that had only 54 miles of range remaining due to the high speed climb up from Black Mountain. 54 miles of range was nowhere near enough to cross “The Wasteland” – that close to 70 mile gap from Black Mountain to Hickory where not a single EV charging station can be found… but I threw caution to the four winds, trusted the science and the car’s technology and my “hyper-mileing” skills…and down I plunged off the edge of the mountains and into the foothills bound for the Piedmont. Then, after dropping over the escarpment – gravity, mass, and momentum coupled with the ingenious science of the regenerative breaking system in the little EV worked together to totally top off the car’s battery upon reaching the bottom!! Wow! The Leaf’s regenerative breaking system had filled the battery all the way back up to full even though the cruise control was set to 60 mph for the entire run down the escarpment–amazing! I then set my sights on Hickory in the distance, set the cruise to 65mph, turned up the stereo, and off I went.
Hickory. 3:58pm. 63 miles driven, 3 miles remaining on GOM!! WOO HOO!! I made it across the wasteland without stopping!!! I rolled into Hickory with only 3 miles of range remaining on the Leaf—now that was close, the lowest I have ever drawn down the Leaf….but I made it across “The Wasteland” at 65 mph!
Now I’m sitting here at Crossroads Nissan plugged into their CHAdeMO quick charger and will be getting back on the road soon to Statesville. I love my car!!
Statesville. 4:58pm. 35 miles driven. 25 miles remaining on GOM!! Made it with no issues. Going to go find food while Elektra suckles the grid from the Level 2 charger at Classic Nissan. Wandered inside to talk to the friendly sales staff and drool over the NV200 delivery van (hopefully soon to be sold in the USA as the eNV200 fully electric small van of which I will one day have for my nonprofit company’s education outreach and wildlife rescue vehicle–read all about it in one of my recent postings.)
Statesville. 7:15pm. Still in Statesville…walked a few blocks down the street for some carnitas and chorizo tacos…car still charging…slowly…seems like this L2 is a bit under-powered…
After an 8:00 departure with around 60 miles available range I headed east on I-40 bound for SciWorks science museum north of Winston Salem where I planned to camp for the night.
West Winston-Salem. 9:00pm. 46 miles driven. 12 miles remaining on GOM!! Made it as far as a Microtel…only about 12 miles short of my destination…just too tired to keep going…been a long day and the Leaf was down to 12 miles of range…and it was dark…and the territory was unfamiliar…so I didn’t want to try to push the envelope like I did earlier crossing the “Wasteland” so I found a hotel on Plugshare where a user stated that they had successfully charged via a 110 outlet on the back of the building…so I booked a room and plugged into the outlet for the night. All in all it has been a successful but long day. I wonder what tomorrow will bring?
8:29 am. Had a decent nights rest at the Microtel and the Leaf charged at L1 for the entire night but only made it to around 75% charge. No problem however since my destination for this morning is the CHAdeMO DCQC at Modern Nissan just a few miles north of the city.
North Winston-Salem. 7:20am. 12 miles driven. 37 miles remaining on GOM!! The drive to Modern Nissan was short and uneventful. I decided to feed the car first but had to squeeze my Leaf into the space that was partially ICE’d (blocked by a gas powered vehicle).
It is charging now so I have some time to ponder the insanity of my surroundings – several older Nissan gas powered vehicles sit in various stages of repair from decades old to shiny new…almost all of them ICE powered… here I sit, charging my all electric intergalactic spacepod of light and wonder (not to be confused with the Intergalactic Spaceboat of Light and Wonder) from yet another technological wonder, the charger…that is unflatteringly installed on top of several wooden pallets and hidden in a remote corner as if they really couldn’t care any less. The people running this establishment and reading these words may not see as I do but as far as I am concerned, the future of passenger transportation is, no, must be the fully electric car powered by renewably generated electricity. There is no other way to get us out of this fossil fired mess we are in. If I was Nissan I would have the DCQC installed prominently out in front of their facility for all to see and would be promoting their EV’s with more gusto….then again, there is the 2nd generation Leaf, the eNV200, and this to look forward to.
Meanwhile, the maintenance staff that has just arrived seems to not share my views as they were all driving large, noisy, modified ICE vehicles that looked like they either had just driven off the set of one of those childish fossil fired Fast and Furious movies or were built to survive an apocalyptic zombie hoard…the one sad thing they all had in common was the huge and loud exhaust pipes. Do they even have any clue about the brilliance of driving electric? I doubt it.
8:15am Even with the range limitations I still love my car….it just finished charging so time for me to go get some fuel for myself now…off to the Waffle House.
Sci-Works. 8:59am. 3 miles driven. After a great Waffle House breakfast I made it to my destination of SCI-WORKS with 66 miles remaining on the GOM.
Modern Nissan. 5:04pm. After a great day of science education I departed SciWorks and headed back to Modern Nissan to top off the battery before heading west to Hickory where I will flop at my sister’s place for the night!
Salisbury. 6:57pm. 41 miles driven. 15 miles remaining on GOM!! I decided to detour to the newly installed Greenlots DCQC in Salisbury for a quick charge while I forage for sustenance on main street…
8:52pm. While the Leaf was fast charging I wandered down a nearby alley to main street, turned left, and found a great Italian restaurant where I had a wonderful vegetarian calzone before getting underway once again.
Statesville. 9:50pm. 25miles driven, 31 miles remaining on GOM!! I made the short run to Statesville where I was not planning to stop but once I hit the city limits and saw the 30 miles of range remaining on the GOM I felt that it was prudent to grab a short charge before pushing on to my sisters place in the backwoods north of Hickory.
10:15pm. The L2 has brought the estimated range up to 60 miles. Time to set out on the 41 mile trek to my sisters home north of Hickory. It will all be secondary roads so the drive should be easy and uneventful…
11:00 pm. My sister’s house somewhere north of Hickory. 41 miles driven, 6 miles remaining on GOM!!! Made it to my sister’s house around 11pm…with 6 miles of range remaining!! Good thing I decided to charge in Statesville! During the charge and subsequent non stop 60 mph 41 mile drive in the country, the temperatures bottomed out around 28f so it is possible that temperature+speed+headlight use+hilly terrain may have been the combined factors that drained the leaf’s battery so fast on this leg of the journey…but I did make it.
I pulled out the extension cord and plugged into a 110v outlet beside the porch and quickly fell asleep on the couch…
9am. This morning the sun cracked over a frosty morning with temps around 25F and a Leaf charged up only to around 65%. I set out on the 14 mile run to the CHAdeMO unit at the Hickory Nissan dealership that I visited on Friday…
Hickory Nissan dealership. 9:45am. 14 miles driven. 35 miles remaining on GOM! At the dealership now charging up as much as possible and planning my route back across “The Wasteland” and then up, up, up the escarpment to my mountain home.
Truthfully, I’m more worried about this leg than any other part of the journey due to the cold temps last night and gradual elevation gain possibly forcing me to stop and trickle charge somewhere in “The “Wasteland”…only time will tell.
10:15am – This quick charge seems to be slower than usual…must be the cold…
Marion. 12:30 pm. 45 miles driven. 7 miles remaining on GOM!
I rolled into Marion around 12:30 pm…with only 7 miles of range remaining! I feared this might happen and here I am – that damn Murphy again. After driving around looking for an outlet and not having much luck and then being turned down by two different small business owners-despite offering to pay them for the electricity – I finally found a place to trickle charge–at the Smokey Que BBQ restaurant. I plugged in and let my car trickle charge while I filled up on a nice lunch of grilled catfish and veggies.
As I ate I calculated just how long it would take to charge the car enough to make the climb up the steep escarpment. At level 1 trickle charge, since there are no L2 charging stations in “The Wasteland,” the remaining distance to the L2 charger in Black Mountain was only about 18 miles away but I needed to factor in not only the distance but the elevation gain up the escarpment and increased speed of interstate driving, so by my rough calculations I would need around a 75% charge to safely get me there with some juice to spare…and to do that in my current charging situation (or lack thereof) I would need to wait for the car to charge for about 8 hours…!
I thought about all of my options and there were only two.
Option 1. Wait for 8 hours then drive to Black Mountain, charge at L2 for about an hour, then make for the DCQC at AB and charge up to 80% and then head home – this option would take me the most time putting me home at probably 1am…but it would also allow me to do the entire trip on electricity so I would have again killed the “white whale” and have some really awesome bragging rights 🙂
Option 2. I could forget my pride and let the whale win for once. Nissan offers, with all EV purchases (at least for now), the option of calling roadside assistance for a tow in the event an EV owner cannot make it to their destination due to either running out of a charge or a lack of charging station infrastructure…my current situation definitely qualified as lack of charging station infrastructure and would have been both had I continued without plugging into the restaurant. I decided to make the decision that I never thought I would need to make – I called Nissan’s roadside assistance and asked for a lift. The operator was very helpful and professional and soon the driver called me back and said it would take him 2 hours before he could get to my location so I pulled out my new Bill Nye book and read a few chapters while I waited.
After reading for awhile I took a walk and soon found myself chatting with the restaurant’s owner who seemed very open and interested in the possibility of installing a Level 2 charging station at his business. If he did so he would not only put his business and town on the navigation systems of every EV in the region but he would also remove “The Wasteland” from the maps and make the drive to the “High country” that much more open to electric vehicles. My challenge to all local EV drivers that are reading this – please, if you ever find yourselves in Marion, make it a point to stop by the Smokey Que BBQ and let the manager know how much an electric vehicle charging station would open up his business and his town to the future–and maybe he will see fit to be the first to do so.
About 1.5 hours later I decided I had enough juice to make the 12 mile drive to Old Fort where it would be easier to meet the tow closer to the interstate so I called the driver to let him know I was moving a few miles up the road.
He soon met me in Old Fort and I snapped this pic of the Leaf being loaded onto the flatbed with Black Mountain looming overhead in the background. At first I regretted having to make the call but later decided that it was a a good test of Nissan’s roadside assistance and I soon discovered that Nissan’s service was smooth, seamless and well orchestrated and if you are an EV owner it is there to help you should you ever need it. Well done Nissan! However, with proper planning you should never need to call for a tow.
The view from the cab of the flatbed as we made our way up the escarpment…
While Nissan’s roadside assistance for EV owners is a complimentary service and my piggyback ride up the mountain was 100 free of cost to me –it was not free of fossil fuel due to the rollback being diesel powered. So this one heavy hauler diesel fired trip most likely negated most if not all the electric driving I had done over the last three days – what a total let down 😦
Live an learn.
The driver soon dropped us off at the AB Technical Community College’s DCQC – the first and last charging stop of the trip. I plugged in and charged up to 80% in 22 minuets and headed home.
Home. 8:15pm. Finally, back at the old home place after an epic 427 mile EV driving and charging adventure that I do not want to repeat anytime soon.
-I only spent $6 on electricity for this entire 427 mile round trip while driving the Leaf. Try that in a gas/diesel vehicle. Had I completed the entire trip without the help from the tow the trip would have been closer to 450 miles…but that is water under the bridge.
-Most of the greenhouse gasses saved by driving the Leaf on this journey were most likely negated by calling for the diesel powered ride up the mountain.
-Detailed trip planning is very important.
-The 2012 Leaf is a wonderful machine in almost every way but it is just not a long-range-at-highway-speeds vehicle. However, if you have access to EVSE charging infrastructure including DC quick chargers spaced about every 50 miles…then it would be doable…although a bit more time consuming.
-Level 1 “trickle” charging is unbelievably, painfully, SLOW! Do it at night while you are sleeping or while you are working.
-Electric cars will often force you to slow down and stop and smell the roses, taste the food, drink the ale, and generally enjoy life a little bit more. This can be very good for business in towns that have charging infrastructure located at or near local businesses.
-Some see an adventure like this as just that–a grand, forward thinking adventure–even with the anxiety that is often inherent with new technologies. Others see it as an impractical waste of time or a massive hindrance–I would be in the former.
-EV battery technology needs to be drastically improved so that EV’s can regularly go over 200 miles on one charge.
-From my experience on this and other long range EV adventures in my Nissan Leaf, as far as I am concerned – even with their limitations (and there are not many) – battery electric EV’s are going to play a major role in the future of automotive transportation.
When will plug in battery electric vehicles begin to dominate the roads? I believe it will happen when all of the factors listed below fall into place;
Battery technology develops to increase range to around 200-300miles/charge.
Charging stations get fast enough to charge an EV to 80% in 10 minuets.
Fast charging infrastructure is more widely developed to fill in the gaps on the maps.
A wider variety of makes and models of BEV’s are offered that appeal to a wider range of buyers. This should include passenger cars, pick-up trucks, delivery vans, motorcycles and luxury super-cars.
More people take a ride in or drive an EV and experience the freedom and joy of driving electric.
From all the hype it looks like 2018 may be the year of the EV if all of the rumors hold true. I suppose we will just have to wait and see.
In the meantime – watch out for white whales.